Kawasaki D-Tracker 125 Fault Codes
Kawasaki D-Tracker 125 motorcycles have engines, which are made up of many different parts. These parts must work together in order for the engine to function. A problem with one of the parts can make the engine not run. There are many different parts that make up an engine. The following kawasaki d-tracker 125 faults are the list of some of the parts of a motorcycle engine.
We’ve compiled a list of some frequently asked questions about Kawasaki D-Tracker 125 motorcycle brakes. This way, you can find answers to some of the most common issues and prepare yourself for the next time you need to take your bike into the shop.
Kawasaki D-Tracker 125 Faults :
The warning light comes on when one of the various sensors has detected an abnormal condition in the Kawasaki D-Tracker 125 engine's performance. For example, if the oil pressure drops below a certain threshold or if the air/fuel ratio rises beyond a certain point, then this would cause an immediate alert from your vehicle's engine management system.
Kawasaki Diagnosis
Under the seat, along the right subframe rail is a short orange/black wire with a bullet connector sticking out of the thick loom. This is the self-diagnosis terminal. There is another bullet connector protruding nearby - make sure it's the orange and black which can take some tugging. In order to read out the Service Codes below, ground that connector with a bit of wire with the motor running.
The red FI light will begin to flash codes. There will be a 5 second delay and then the codes begin. The first flash is always a LONG (1 sec) followed by either LONG or SHORT (0.5 sec) flashes. LONG flashes indicate TENS and short flashes ONES.
One LONG followed by two SHORT = 12. Two LONG, one SHORT = 21. Three LONG, two short = 32, etc. There is an interval of 1.5 seconds between TENS and ONES. There is a 3 second interval between codes.
To recover codes set in memory ground the self-diagnosis terminal rapidly more than 5 times within 2 seconds. The lead must remain grounded after 5 groundings for the remainder of the diagnostic session. You can then clear codes from the ECU by pulling the clutch lever in for more than 5 seconds.
KAWASAKI Motorcycles Fault Codes DTC List
Trouble Code | Problem Description |
---|---|
11 | Main throttle sensor malfunction, wiring open or short |
12 | Inlet air pressure sensor malfunction, wiring open or short |
13 | Inlet air temperature sensor malfunction, wiring open or short |
14 | Water temperature sensor malfunction, wiring open or short |
15 | Atmospheric pressure sensor malfunction, wiring open or short |
21 | Crankshaft sensor malfunction, wiring open or short |
23 | Camshaft position sensor malfunction, wiring open or short |
24 | Speed sensor malfunction, wiring open or short |
25 | Gear position switch malfunction, wiring open or short |
31 | Vehicle-down sensor malfunction, wiring open or short |
32 | Subthrottle sensor malfunction, wiring open or short |
33 | Oxygen sensor #1 inactivation, wiring open or short (Equipped Models) |
34 | Exhaust butterfly valve actuator sensor malfunction, wiring open or short |
35 | Immobilizer amplifier malfunction |
36 | Blank Key detection |
39 | ECU communication error |
51 | Stick coil #1 malfunction, wiring open or short |
52 | Stick coil #2 malfunction, wiring open or short |
53 | Stick coil #3 malfunction, wiring open or short |
54 | Stick coil #4 malfunction, wiring open or short |
56 | Radiator fan relay malfunction, wiring open or short |
62 | Subthrottle valve actuator malfunction, wiring open or short |
63 | Exhaust butterfly valve actuator malfunction, wiring open or short |
64 | Air switching valve malfunction, wiring open or short |
67 | Oxygen sensor heater malfunction, wiring open or short (Equipped Models) |
83 | Oxygen Sensor #2 inactivation, wiring open or shout (Equipped Models) |
94 | Oxygen sensor #1 malfunction, wiring open or short (Equipped Models) |
95 | Oxygen sensor #2 malfunction, wiring open or short (Equipped Models) |
Kawasaki D-Tracker 125 Motorcycle Problems :
- Kawasaki d-tracker 125 after fire
- Kawasaki d-tracker 125 air cleaner clogged, poorly sealed, or missing
- Kawasaki d-tracker 125 air cleaner element clogged
- Kawasaki d-tracker 125 air duct loose
- Kawasaki d-tracker 125 air suction valve trouble
- Kawasaki d-tracker 125 air switching valve trouble
- Kawasaki d-tracker 125 backfiring when deceleration
- Kawasaki d-tracker 125 cracked or obstructed intake air pressure sensor
- Kawasaki d-tracker 125 crankshaft sensor trouble
- Kawasaki d-tracker 125 eCU ground and power supply trouble
- Kawasaki d-tracker 125 eCU trouble
- Kawasaki d-tracker 125 engine overheating - Water temperature sensor or crankshaft sensor trouble
- Kawasaki d-tracker 125 engine stalls easily
- Kawasaki d-tracker 125 engine vacuum not synchronizing
- Kawasaki d-tracker 125 exhaust Smokes Excessively
- Kawasaki d-tracker 125 firing incorrect
- Kawasaki d-tracker 125 fuel filter clogged
- Kawasaki d-tracker 125 fuel injector clogged
- Kawasaki d-tracker 125 fuel injector O-ring damage
- Kawasaki d-tracker 125 fuel injector trouble
- Kawasaki d-tracker 125 fuel line clogged
- Kawasaki d-tracker 125 fuel poor quality or incorrect
- Kawasaki d-tracker 125 fuel pressure regulator trouble
- Kawasaki d-tracker 125 fuel pressure too low or too high
- Kawasaki d-tracker 125 fuel pump bearings may wear. Replace the fuel pump
- Kawasaki d-tracker 125 fuel pump not operating
- Kawasaki d-tracker 125 fuel pump operates intermittently and often DFI fuse blows
- Kawasaki d-tracker 125 fuel pump relay trouble
- Kawasaki d-tracker 125 fuel pump trouble
- Kawasaki d-tracker 125 fuel/air mixture incorrect
- Kawasaki d-tracker 125 fuel/air mixture incorrect
- Kawasaki d-tracker 125 gear position sensor, starter lockout or side stand switch trouble
- Kawasaki d-tracker 125 inspect and repair or replace
- Kawasaki d-tracker 125 intake air pressure sensor trouble
- Kawasaki d-tracker 125 intake air temperature sensor trouble
- Kawasaki d-tracker 125 intake air temperature sensor trouble
- Kawasaki d-tracker 125 intermittent any DFI fault and its recovery
- Kawasaki d-tracker 125 little fuel in tank
- Kawasaki d-tracker 125 main throttle sensor trouble
- Kawasaki d-tracker 125 no or little fuel in tank
- Kawasaki d-tracker 125 poor acceleration
- Kawasaki d-tracker 125 spark plug burned or gap maladjusted
- Kawasaki d-tracker 125 spark plug dirty, broken or gap maladjusted
- Kawasaki d-tracker 125 spark plug incorrect
- Kawasaki d-tracker 125 spark weak
- Kawasaki d-tracker 125 stick coil shorted or not in good contact
- Kawasaki d-tracker 125 stick coil trouble
- Kawasaki d-tracker 125 subthrottle sensor trouble
- Kawasaki d-tracker 125 subthrottle valve actuator trouble
- Kawasaki d-tracker 125 throttle body assy dust seal damage
- Kawasaki d-tracker 125 throttle body assy holder loose
- Kawasaki d-tracker 125 throttle valves will not fully open
- Kawasaki d-tracker 125 unstable (rough) idling
- Kawasaki d-tracker 125 unstable fuel pressure
- Kawasaki d-tracker 125 vacuum hose
- Kawasaki d-tracker 125 vehicle-down sensor trouble
- Kawasaki d-tracker 125 water or foreign matter in fuel Change fuel
- Kawasaki d-tracker 125 water temperature sensor trouble
The first sign that your Kawasaki D-Tracker 125 motorcycle's starter system is working well is the warning light that appears when you switch on the ignition. It will illuminate for a few seconds, and then go out. This is a good sign that your starter system is working properly and you'll be able to start your motorcycle without difficulty.
Possible Failure Types :
- Strange Kawasaki D-Tracker 125 engine noise.
- Kawasaki D-Tracker 125 fog from engine.
- Strange Kawasaki D-Tracker 125 engine noise.
- Kawasaki D-Tracker 125 Vibrations and Rattling
- Kawasaki D-Tracker 125 Loud Acceleration
- Kawasaki D-Tracker 125 rusty exhaust
- Kawasaki D-Tracker 125 blockages in exhaust pipe
- Kawasaki D-Tracker 125 wear and tear exhaust

Kawasaki Heavy Industries was started in 1878, as a producer of maritime equipment and vessels. Kawasaki began motorcycle manufacturing in the late 1960’s and today, their bikes are famous for being nearly bulletproof, and many of their models being friendly for new riders.
Check other Kawasaki fault codes.Common abbreviations and their meanings below:
ABS: Anti-Lock Braking System ACR: Automatic Compression Release AFR: Air Fuel Ratio AIS: Active Intake Solenoid ATS: Air Temperature Sensor BAS: Bank Angle Sensor BCM: Body Control Module CAN: Controller Area Network CCM: Cruise Control Module CKP: Crank Position Sensor DLC: Datalink Connector DTC: Diagnostic Trouble Codes ECM: Electronic Control Module ECT: Engine Coolant Temperature ECU: Electronic Control Unit EFI: Electronic Fuel Injection EFP: Electronic Fuel Pump ET: Engine Temperature sensor FI: Fuel Injectors FPR: Fuel Pressure Regulator H-DSSS: Harley-Davidson® Smart Security System HCU: Hydraulic Control Unit, ABS HFSM: Hands Free Security Module HO2S: Heated Oxygen Sensor IAC: Idle Air Control actuator IAT: Intake Air Temperature sensor ICM: Ignition Control Module IMAP: MAP + IAT in one unit ISS: Ion Sensing System JSS: Jiffy Stand Sensor LHCM: Left Hand Control Module MAP: Manifold Absolute Pressure sensor MHR: Right Hand Control Module RCM: Reverse Control Module TCA: Throttle Control Actuator TGS: Twist Grip Sensor TMAP: Intake Air Temperature / Manifold Absolute Pressure equipment TPS: Throttle Position Sensor TSM / TSSM: (Turn Signal / Turn Signal Security Module) VE: Volume Efficiency VIN: Vehicle Identification Number VSS: Vehicle Speed Sensor WSS: Wheel Speed Sensor
These abbreviations, and the accompanying list of trouble codes, can be a great start when your Kawasaki check engine light comes on. As mentioned above, if you are not comfortable with electrical diagnostic work, a dealership or qualified technician can offer assistance. Please keep in mind that even though you have the ability to clear a DTC using the onboard diagnostic feature, you shouldn't clear the code prior to your service appointment. Let the technician view and clear the codes as they troubleshoot the issue.
Kawasaki and logo are registered trademarks of Kawasaki. We are fan of MOTORCYCLES ! We love them.