Kawasaki KX 125 Fault Codes

Kawasaki KX 125 motorcycles have engines, which are made up of many different parts. These parts must work together in order for the engine to function. A problem with one of the parts can make the engine not run. There are many different parts that make up an engine. The following kawasaki kx 125 faults are the list of some of the parts of a motorcycle engine.

We’ve compiled a list of some frequently asked questions about Kawasaki KX 125 motorcycle brakes. This way, you can find answers to some of the most common issues and prepare yourself for the next time you need to take your bike into the shop.

Kawasaki KX 125 Faults :

Your bike engine consists of a great deal of elements like the casting, cylinder heads and pistons. it's necessary to form certain these area unit all clean and lubricated to avoid engine issues. Conjointly keep in mind that Kawasaki KX 125 motorbike engine could be a terribly delicate piece of machinery therefore it is best to handle it with care.

Kawasaki Diagnosis

Under the seat, along the right subframe rail is a short orange/black wire with a bullet connector sticking out of the thick loom. This is the self-diagnosis terminal. There is another bullet connector protruding nearby - make sure it's the orange and black which can take some tugging. In order to read out the Service Codes below, ground that connector with a bit of wire with the motor running.

The red FI light will begin to flash codes. There will be a 5 second delay and then the codes begin. The first flash is always a LONG (1 sec) followed by either LONG or SHORT (0.5 sec) flashes. LONG flashes indicate TENS and short flashes ONES.

One LONG followed by two SHORT = 12.
Two LONG, one SHORT = 21.
Three LONG, two short = 32, etc.
There is an interval of 1.5 seconds between TENS and ONES.
There is a 3 second
interval between codes.

To recover codes set in memory ground the self-diagnosis terminal rapidly more than 5 times within 2 seconds. The lead must remain grounded after 5 groundings for the remainder of the diagnostic session. You can then clear codes from the ECU by pulling the clutch lever in for more than 5 seconds.

KAWASAKI Motorcycles Fault Codes DTC List

Trouble CodeProblem Description
11Main throttle sensor malfunction, wiring open or short
12Inlet air pressure sensor malfunction, wiring open or short
13Inlet air temperature sensor malfunction, wiring open or short
14Water temperature sensor malfunction, wiring open or short
15Atmospheric pressure sensor malfunction, wiring open or short
21Crankshaft sensor malfunction, wiring open or short
23Camshaft position sensor malfunction, wiring open or short
24Speed sensor malfunction, wiring open or short
25Gear position switch malfunction, wiring open or short
31Vehicle-down sensor malfunction, wiring open or short
32Subthrottle sensor malfunction, wiring open or short
33Oxygen sensor #1 inactivation, wiring open or short (Equipped Models)
34Exhaust butterfly valve actuator sensor malfunction, wiring open or short
35Immobilizer amplifier malfunction
36Blank Key detection
39ECU communication error
51Stick coil #1 malfunction, wiring open or short
52Stick coil #2 malfunction, wiring open or short
53Stick coil #3 malfunction, wiring open or short
54Stick coil #4 malfunction, wiring open or short
56Radiator fan relay malfunction, wiring open or short
62Subthrottle valve actuator malfunction, wiring open or short
63Exhaust butterfly valve actuator malfunction, wiring open or short
64Air switching valve malfunction, wiring open or short
67Oxygen sensor heater malfunction, wiring open or short (Equipped Models)
83Oxygen Sensor #2 inactivation, wiring open or shout (Equipped Models)
94Oxygen sensor #1 malfunction, wiring open or short (Equipped Models)
95Oxygen sensor #2 malfunction, wiring open or short (Equipped Models)

Kawasaki KX 125 Motorcycle Problems :

  • Kawasaki kx 125 after fire
  • Kawasaki kx 125 air cleaner clogged, poorly sealed, or missing
  • Kawasaki kx 125 air cleaner element clogged
  • Kawasaki kx 125 air duct loose
  • Kawasaki kx 125 air suction valve trouble
  • Kawasaki kx 125 air switching valve trouble
  • Kawasaki kx 125 backfiring when deceleration
  • Kawasaki kx 125 cracked or obstructed intake air pressure sensor
  • Kawasaki kx 125 crankshaft sensor trouble
  • Kawasaki kx 125 eCU ground and power supply trouble
  • Kawasaki kx 125 eCU trouble
  • Kawasaki kx 125 engine overheating - Water temperature sensor or crankshaft sensor trouble
  • Kawasaki kx 125 engine stalls easily
  • Kawasaki kx 125 engine vacuum not synchronizing
  • Kawasaki kx 125 exhaust Smokes Excessively
  • Kawasaki kx 125 firing incorrect
  • Kawasaki kx 125 fuel filter clogged
  • Kawasaki kx 125 fuel injector clogged
  • Kawasaki kx 125 fuel injector O-ring damage
  • Kawasaki kx 125 fuel injector trouble
  • Kawasaki kx 125 fuel line clogged
  • Kawasaki kx 125 fuel poor quality or incorrect
  • Kawasaki kx 125 fuel pressure regulator trouble
  • Kawasaki kx 125 fuel pressure too low or too high
  • Kawasaki kx 125 fuel pump bearings may wear. Replace the fuel pump
  • Kawasaki kx 125 fuel pump not operating
  • Kawasaki kx 125 fuel pump operates intermittently and often DFI fuse blows
  • Kawasaki kx 125 fuel pump relay trouble
  • Kawasaki kx 125 fuel pump trouble
  • Kawasaki kx 125 fuel/air mixture incorrect
  • Kawasaki kx 125 fuel/air mixture incorrect
  • Kawasaki kx 125 gear position sensor, starter lockout or side stand switch trouble
  • Kawasaki kx 125 inspect and repair or replace
  • Kawasaki kx 125 intake air pressure sensor trouble
  • Kawasaki kx 125 intake air temperature sensor trouble
  • Kawasaki kx 125 intake air temperature sensor trouble
  • Kawasaki kx 125 intermittent any DFI fault and its recovery
  • Kawasaki kx 125 little fuel in tank
  • Kawasaki kx 125 main throttle sensor trouble
  • Kawasaki kx 125 no or little fuel in tank
  • Kawasaki kx 125 poor acceleration
  • Kawasaki kx 125 spark plug burned or gap maladjusted
  • Kawasaki kx 125 spark plug dirty, broken or gap maladjusted
  • Kawasaki kx 125 spark plug incorrect
  • Kawasaki kx 125 spark weak
  • Kawasaki kx 125 stick coil shorted or not in good contact
  • Kawasaki kx 125 stick coil trouble
  • Kawasaki kx 125 subthrottle sensor trouble
  • Kawasaki kx 125 subthrottle valve actuator trouble
  • Kawasaki kx 125 throttle body assy dust seal damage
  • Kawasaki kx 125 throttle body assy holder loose
  • Kawasaki kx 125 throttle valves will not fully open
  • Kawasaki kx 125 unstable (rough) idling
  • Kawasaki kx 125 unstable fuel pressure
  • Kawasaki kx 125 vacuum hose
  • Kawasaki kx 125 vehicle-down sensor trouble
  • Kawasaki kx 125 water or foreign matter in fuel Change fuel
  • Kawasaki kx 125 water temperature sensor trouble

Fault problems that can occur with yourKawasaki KX 125motorcycle engine is a blown head gasket. This can cause your engine to overheat and possibly crack the cylinder heads. In this case, it is best to take your Kawasaki KX 125 motorcycle to a professional mechanic to have it checked out. Another common problem is with the carburetor. The carburetor is the part of your motorcycle that mixes air and fuel to create the combustion needed to power the engine.

Possible Failure Types :

  • Strange Kawasaki KX 125 engine noise.
  • Kawasaki KX 125 fog from engine.
  • Strange Kawasaki KX 125 engine noise.
  • Kawasaki KX 125 Vibrations and Rattling
  • Kawasaki KX 125 Loud Acceleration
  • Kawasaki KX 125 rusty exhaust
  • Kawasaki KX 125 blockages in exhaust pipe
  • Kawasaki KX 125 wear and tear exhaust
Kawasaki Logo

Kawasaki Heavy Industries was started in 1878, as a producer of maritime equipment and vessels. Kawasaki began motorcycle manufacturing in the late 1960’s and today, their bikes are famous for being nearly bulletproof, and many of their models being friendly for new riders.

Check other Kawasaki fault codes.

Common abbreviations and their meanings below:

ABS: Anti-Lock Braking System
ACR: Automatic Compression Release
AFR: Air Fuel Ratio
AIS: Active Intake Solenoid
ATS: Air Temperature Sensor
BAS: Bank Angle Sensor
BCM: Body Control Module
CAN: Controller Area Network
CCM: Cruise Control Module
CKP: Crank Position Sensor
DLC: Datalink Connector
DTC: Diagnostic Trouble Codes
ECM: Electronic Control Module
ECT: Engine Coolant Temperature
ECU: Electronic Control Unit
EFI: Electronic Fuel Injection
EFP: Electronic Fuel Pump
ET: Engine Temperature sensor
FI: Fuel Injectors
FPR: Fuel Pressure Regulator
H-DSSS: Harley-Davidson® Smart Security System
HCU: Hydraulic Control Unit, ABS
HFSM: Hands Free Security Module
HO2S: Heated Oxygen Sensor
IAC: Idle Air Control actuator
IAT: Intake Air Temperature sensor
ICM: Ignition Control Module
IMAP: MAP + IAT in one unit
ISS: Ion Sensing System
JSS: Jiffy Stand Sensor
LHCM: Left Hand Control Module
MAP: Manifold Absolute Pressure sensor
MHR: Right Hand Control Module
RCM: Reverse Control Module
TCA: Throttle Control Actuator
TGS: Twist Grip Sensor
TMAP: Intake Air Temperature / Manifold Absolute Pressure equipment
TPS: Throttle Position Sensor
TSM / TSSM: (Turn Signal / Turn Signal Security Module)
VE: Volume Efficiency
VIN: Vehicle Identification Number
VSS: Vehicle Speed Sensor
WSS: Wheel Speed Sensor

These abbreviations, and the accompanying list of trouble codes, can be a great start when your Kawasaki check engine light comes on. As mentioned above, if you are not comfortable with electrical diagnostic work, a dealership or qualified technician can offer assistance. Please keep in mind that even though you have the ability to clear a DTC using the onboard diagnostic feature, you shouldn't clear the code prior to your service appointment. Let the technician view and clear the codes as they troubleshoot the issue.

Kawasaki and logo are registered trademarks of Kawasaki. We are fan of MOTORCYCLES ! We love them.

Motorcycle electrical systems are very complex to fix it, check with your motorcycle diagnosis tool for the fault code and start motorcycle troubleshooting process.Some bike problems require professional troubleshooting and repair. However, there are many issues that you can easily fix on your own.

About Us | Contact | Privacy

Copyright 2022 - © MotorcycleTroubleshooting.com